Two-brothers-racing Triumph Daytona 675 - CA Emissions Legal Manuel d'utilisateur télécharger pdf

Two Brothers Racing

Juice Box™ - Fuel Controller

2006-08 Triumph Daytona 675 Installation & Operation Manual

Part # 008-155C

Parts Incuded

Installation Instructions

Qty. Description Part Number

1 Juice Box™ Fuel Control Kit 008-155C

(#9130003C)

3 Zip Ties

1 Adhesive Velcro Square

V.A.L.E .

V A R I A B L E A X I S L O C K I N G E X H A U S T

Route the JUICE BOX™ harness under the fuel tank

toward the rear of the bike and mount under the front

seat. Tuck the wiring in to prevent pinching under the tank.

Connect the JUICE BOX™ ground to the battery negative.

(Fig 4)

Start the bike. The green LED should now be scrolling for

about 3-5 seconds and then go to 1-2 steady green LED’s

or a single slow ﬂashing green LED. If the number 1 green

and number 8 red LED continue ﬂashing after startup,

an injector wiring error is indicated. Re-check the wires

from the JUICE BOX™ and make sure they are connected

to the proper wires of your bike’s stock harness. MAKE

SURE you have the correct connectors selected in the

stock harness. DO NOT PROCEED UNLESS ABOVE

CONDITIONS ARE MET.

Reassembly is the opposite of disassembly.

NOTE: Re check your wire routing and JUICE BOX™

location and make certain that in no way the wires can

come into contact with any moving parts or high heat

source and that the JUICE BOX™ is mounted in a way as

to not cause a handling problem with the machine.

IMPORTANT - PLEASE READ CAREFULLY

Warranty

Two Brothers Racing warrants that this product carries a warranty for 2 years from date of purchase against original

defects in materials and workmanship. Should this product fail to perform for either of the above reasons, Two Brothers

Racing will repair or replace it with an equivalent product at no charge, except for postage, to the original retail purchaser.

To obtain the benefits of this warranty, the retail purchaser must return the product and proof of purchase to the place of

original purchase.

We recommend that this performance part be installed by a qualied motorcycle

technician. If you have any doubts as to your ability to install this performance part,

please consult with your local motorcycle dealer. Read all instructions rst before

starting installation. Make sure the vehicle and exhaust system are completely cool

before starting the installation. Also, make sure the vehicle is secure during installation.

Be sure to save all stock components for possible use later.

This Juice Box is legal for use on Emissions Controlled street and highway vehicles.

The Juice Box™ is not applicable, nor inteded for use on aircraft.

Thank you for purchasing a genuine Two Brothers Racing

JUICE BOX™. This product represents a radical step

forward in tuning fuel-injected motorcycles and ATVs for

optimal performance using “load-based” technology.

We at Two Brothers Racing hope that you will ﬁnd this

development as exciting and useful as we do. And

remember: Proper Fuel = Maximum Power!

Make sure the vehicle is completely cool before starting

the installation. Also, make sure the vehicle is secure and

will not roll around.

Remove the front seat.

Remove tank bolts near steering stem. (Fig 1)

Gently rotate fuel tank toward the rear and support. (Fig 2)

Remove the injector connectors one at a time. There are

three injector connectors. Connect the JUICE BOX™

harness to the injector, and the stock injector connector to

the JUICE BOX™ harness. (Fig 3)

Continued on page 2

Fig 1

Fig 4

Fig 2

Fig 3

1 2 3

Résumé du contenu

Page 1 - V.A.L.E

Two Brothers RacingJuice Box™ - Fuel Controller2006-08 Triumph Daytona 675 Installation & Operation ManualPart # 008-155CParts IncudedInstallation

Page 2 - Juice Box™ - Fuel Controller

Operation Manual II. The second mode (Yellow Mode) represents an additional amount of fuel added during acceleration. A ﬂashing yellow LED should a

Page 3

Operation Manual - JUICE BOX™ SettingsMode 1 - GreenMode 4 - Green Mode 5 - Yellow/Blue Mode 6 - Red/BlueMode 2 - Yellow Mode 3 - Red(2006-08) Daytona

Commentaires sur ces manuels

Pas de commentaire

Two-brothers-racing Triumph Daytona 675 - CA Emissions Legal Manuel d'utilisateur

Naviguer en ligne ou télécharger Manuel d'utilisateur pour Capteurs Two-brothers-racing Triumph Daytona 675 - CA Emissions Legal. Two Brothers Racing Triumph Daytona 675 - CA Emissions Legal User Manual Manuel d'utilisatio

Résumé du contenu

Commentaires sur ces manuels

Produits connexes et manuels pour Capteurs Two-brothers-racing Triumph Daytona 675 - CA Emissions Legal